Product ID:605412005 VULKEM 200
MSDS Date:11/07/1985
FSC:8040
NIIN:00F037239
MSDS Number: BVTKN

RPM MAMECO INTERNATIONAL

4475 E 175TH ST
CLEVELAND, OH 44128-3411
US

Emergency Phone: 216-752-4400

Info Phone: 216-752-4400

Cage: GO142

RPM MAMECO INTERNATIONAL

CLEVELAND, OH 44128-3411 US

Telephone: 216-752-4400

Cage: GO142

COAL TAR (CARCINOGEN BY NTP) *94-3*

CAS: 65996-89-6

RTECS: GF8600100

Fraction By Weight: 50%

OSHA PEL 0.2 MG/CUM

ACGIH TLV: 0.2 MG/CUM

AROMATIC HYDROCARBONS

Fraction By Weight: 20%

ACGIH TLV: 0.2 MG/CUM

ISOCYANATE COMPOUNDS

Fraction By Weight: <5%

ACGIH TLV: 0.02 PPM

XYLENE, DIMETHYLBENZENE, XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:VAPORS ARE IRRITATING WHEN HOT. LOW
ORDER OF ACUTE ORAL & SKIN TOXICITY. MAY BE IRRITATING TO
RESPIRATORY TRACT & EYES. CERTAIN AROMATIC HYDROCARBONS HAVE BEEN
SHOWN TO CAUSE CANCER AFTER PROLONGED/RE PEATED CONTACT.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:VAPORS ARE IRRITATING WHEN HOT. LOW ORDER OF
ACUTE ORAL & SKIN TOXICITY. MAY BE IRRITATING TO RESPIRATORY TRACT
& EYES. CERTAIN AROMATIC HYDROCARBONS HAVE BEEN SHOWN TO CAUSE
CANCER AFTER PROLONGED/RE PEATED CONTACT.

First Aid:SKIN: THOROUGHLY WASH EXPOSED AREA W/SOAP & WATER. EYES:
FLUSH W/LARGE AMOUNTS OF WATER. INGESTION: DON'T INDUCE VOMITING.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED. OBTAIN
MEDICAL AT TENTION IN ALL CASES.

Flash Point:190F
Extinguishing Media:WATERSPRAY, WATERFOG, DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR GOGGLES, SCBA, & FULL PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:REACTION W/WATER PRODUCES CO2 WHICH COULD
CAUSE PRESSURE TO BUILD IN A CLOSED CONTAINER.

Spill Release Procedures:ABSORB INTO VERMICULITE/OTHER ABSORBENT
MATERIAL & DISPOSE. CLEAN AFFECTED AREA W/SOLVENT FOLLOWED BY SOAP
& WATER.

Handling and Storage Precautions:STORE AT TEMP <180F/AWAY FROM
SPARKS/FLAME. FOR MAXIMUM STORAGE LIFE STORE <90F. PROTECT
CONTAINERS FROM DAMAGE.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. DON'T BREATH
VAPORS. AVOID SKIN & EYE CONTACT. DON'T TAKE INTERNALLY.

Respiratory Protection:USE W/ADEQUATE VENTILATION. RESPIRATORS
W/ORGANIC VAPOR CARTRIDGES/SCBA MAY BE USED IN CONFINED AREAS.
Ventilation:LOCAL EXHAUST/GENERAL MECHANICAL SUFFICIENT TO PREVENT
ACCUMULATION OF FUMES.
Protective Gloves:PLASTIC/RUBBER/BUNA-N
Eye Protection:GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Supplemental Safety and Health

Boiling Pt:B.P. Text:280F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:15

Stability Indicator/Materials to Avoid:YES
ALCOHOLS, STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS.
Stability Condition to Avoid:SPARKS, FLAME, WATER
Hazardous Decomposition Products:NITROGEN OXIDES, HYDROGEN CYANIDE, CO,
CO2.

Waste Disposal Methods:INCINERATE/LANDFILL IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.